Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Plans to distribute 1st doses of the Johnson & Johnson COVID-19 vaccine on hold

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility

Plans to distribute the first 300,000 doses of the Johnson & Johnson COVID-19 vaccine next week are on hold after Health Canada learned part of them were manufactured at a Maryland facility that messed up the ingredients in 15 million doses bound for the U.S. market.

The Emergent Biosolutions facility in Baltimore was recently cited by the U.S. Food and Drug Administration for violations including cleaning and sterilization failures, the potential for cross-contamination and failure to follow required protocols.

The FDA ordered the facility to stop making more J&J vaccine until the problems are corrected and the earlier mistake on the doses resulted in all 15 million being destroyed.

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility, but did not think the Canadian J&J doses had any connection to that plant.

Now Health Canada says the drug substance that makes up part of the J&J vaccine was actually produced there and then shipped elsewhere for the vaccines to be finished.

Health Canada says it is seeking information from the FDA and J&J’s pharmaceutical arm, Janssen, to determine if the 300,000 doses shipped to Canada meet required safety standards.

“As with all vaccines imported into Canada, the Janssen vaccines will only be released for distribution once Health Canada is satisfied that they meet the Department’s high standards for quality, safety and efficacy,” Health Canada said Friday evening in a release.

“Health Canada has rigorous processes in place to continually monitor the quality of vaccines that are administered to Canadians.

“We will continue to ensure that products coming from the Emergent facility, or any other facility, will only be imported and distributed in Canada if they are of high quality and safe for use.”

Until Friday, Health Canada had refused to say where Canada’s doses had been made, citing fear of disrupting a confidential supply chain.

The J&J vaccine has not been used in Canada so far, and the National Advisory Committee on Immunization hasn’t yet provided guidance on how they think it should be used.

The doses arrived in Canada on Wednesday and are in holding at the Innomar Strategies facility near Toronto’s Pearson airport. Innomar is contracted to receive and redistribute all vaccines in Canada, except Pfizer-BioNTech. That vaccine is shipped directly to provincial governments.

The Canadian Press

Like us on Facebook and follow us on Twitter.

Want to support local journalism? Make a donation here.

Coronavirus

Just Posted

The first Pfizer-BioNTech COVID-19 vaccine dose in Canada is prepared at The Michener Institute in Toronto on Monday, Dec. 14, 2020. THE CANADIAN PRESS/Frank Gunn
One death, 39 new cases of COVID-19 in Interior Health

There are 484 active cases of the virus in the region currently

A health-care worker prepares a dose of the Pfizer-BioNTech COVID-19 vaccine at a COVID-19 vaccine clinic in Toronto on Thursday, January 7, 2021. THE CANADIAN PRESS/Nathan Denette
65 new cases of COVID-19 in Interior Health

Overall, B.C. is seeing a decrease in COVID-19 cases

FILE - In this April 19, 2021, file photo, Keidy Ventura, 17, receives her first dose of the Pfizer COVID-19 vaccine in West New York, N.J. States across the country are dramatically scaling back their COVID-19 vaccine orders as interest in the shots wanes, putting the goal of herd immunity further out of reach. (AP Photo/Seth Wenig, File)
5 more deaths, 131 new cases of COVID-19 in Interior Health over the weekend

Those 18-years and older in high-transmission neighbourhoods can register for the vaccine

A medical worker prepares vials of the COVID-19 vaccines, Chinese Sinopharm, left, Sputnik V, center, and Pfizer at a vaccine centre, in the Usce shopping mall in Belgrade, Serbia, Thursday, May 6, 2021. Serbian authorities are looking for incentives for people to boost vaccination that has slowed down in recent weeks amid widespread anti-vaccination and conspiracy theories in the Balkan nation. The government has also promised a payment of around 25 euros to everyone who gets vaccinated by the end of May. (AP Photo/Darko Vojinovic)
38 new COVID-19 cases, more than 335k vaccines administered in Interior Health

Interior Health also to start targeted vaccinations in high transmission neighbourhoods

FILE PHOTO
Second doses of COVID-19 vaccine will be available, as AstraZeneca supply runs low: Interior Health

Province expecting large volumes of Pfizer BioNTech as age-based cohort immunization program ramps up

B.C. Labour Minister Harry Bains in the B.C. legislature, May 13, 2019. (Hansard TV)
VIDEO: B.C. to provide 3 days of sick pay for COVID-19 absences

Province will support employers on cost, labour minister says

BC Housing minister David Eby. (THE CANADIAN PRESS/Chad Hipolito)
Eby jabs back against Penticton mayor’s ad urging BC Premier to intervene in shelter dispute

Eby writes that Penticton’s ‘serious’ social issues won’t improve under leadership of the mayor

Provincial health officer Dr. Bonnie Henry updates B.C.’s COVID-19 situation at the B.C. legislature, April 29, 2021. (B.C. government)
B.C.’s COVID-19 rate creeps up again, 600 new cases Wednesday

One more death, 423 people in hospital with virus

B.C. Agriculture Minister Lana Popham takes questions in the B.C. legislature in 2017. (Hansard TV)
UPDATE: B.C. will fund another year of fresh fruit, vegetables, milk in schools

John Horgan government working on school meal program

Surrey RCMP is releasing sketches of a suspect in an “indecent act” at the Coyote Creek Elementary playground on April 30, 2021. Police said the suspect was clean-shaven “during some interactions” and on “other occasions had stubble outlining a goatee and mustache.” (Images: Surrey RCMP handout)
Vancouver mayor-elect Kennedy Stewart addresses supporters in Vancouver on Sunday, Oct. 21, 2018. THE CANADIAN PRESS/Darryl Dyck
Vancouver mayor says there’s no time to redo details of drug decriminalization plan

Kennedy Stewart says a federal election could see the small window of opportunity close on the city’s bid for an exemption from criminal provisions on simple possession of small amounts of drugs

Premier Mike Horgan received his first dose of a COVID-19 vaccine. (Facebook/John Horgan)
More than 50% of people eligible in B.C. have received 1st vaccine dose

‘We’ve made extraordinary progress together over the past few weeks,’ says Premier Horgan

Brad MacKenzie, advocacy chair for the ALS Society of B.C., says having research projects in the province allows people here to have access to cutting-edge treatments now being developed. (B.C. government video)
B.C. funds research chair for Lou Gehrig’s disease at UBC

Pandemic has cut off patient access to international projects

Most Read